摘要廠家,2020NA推薦產品,生物質鍋爐脈沖除塵器,燃煤鍋爐，生物質蒸拂配TA-O除塵器，熱風爐除塵器

根據鍋爐燃料，鍋爐噸位，DMC,PPC,LMCD的除塵器，由型至中型至大型除塵器組成。

DMCPMD-MD系列噴傣沖單機袋式收塵器

DMCPMD-MDSeries Jet-Pulse Unit Bag Filter

概述Introduction

lPDMDMC系列噴傣沖單機袋式收塵器適用于破碎′送♂升′料、庫高、庫底‘泥散裝等茨粉塵治理，可以連續工作，無須停機清灰

l收塵器可分成不同的安裝形式不帶灰斗及支腿型B型灰斗及支腿型A型；風機可90、0，根據需要選擇

l壓縮空氣必須保證0.5-0.7MPa的壓力，否則影響清灰效果

l除塵器本體采用碳鋼』銹鋼等材質

lPMDDMCseries jet-pulse unit bag filter is applicable for dust collecting in various sections, such as crushing, conveying, elevating, proportioning, silo top, silo bottom and bulk cement. It could operate continuously without necessity to stop the equipment for removing dust.

lThe dust collector could be erectly in different ways: without hopper and bracingB model; with hopper and long bracingA model; Fans can be set in 90and 0angles depending on requirements.

lPressure of compressed air should be ensured within0.5-0.7MPA，or else operation for removing dust would not be efficient.

lUse the material such as carbon steel, stainless steel filter ontology.

特點介紹Characteristics

l一般采用上箱體高設可掀起的蓋板用于檢修及更換濾袋，若空間受限可采用側開門以便檢修更換濾袋。

l濾袋用特制的彈簧脹圈固定在多孔板上，旋風除塵器-河北富宇環保設備有限公司，濾袋內安裝有金屬框架和文氏管。

l采用微機自動控制清灰

l安裝有防濾袋脫落，更適合庫高使用

lGeneral use case on the top cover plate for convenient maintenance and replacement of bag.Ifthe space is limited side door can be used to repair replace the filter bag.

lFilter bag with a special spring ring fixed on the perforated plate ,Metal frame and pipe installation within the filter bag

lDust removal is controlled by computer automatically.

lA net is installed to avoid bag’s falling down to silo. It is more suitable for operation on top of silo.

技術指標Technical Indexes

l收塵器入口含塵濃度一般低于200g/Nm3

l收塵器排放濃度低于30mg/Nm3

l收塵器濾袋壽命兩NA以上

l收塵器運轉率相對主機

lDust concentration at inlet is below 200 g/Nm3.

lEmission concentration is below 20 mg/Nm3.

lService life of filter bags is over 2 years.

lThe operation rate of bag filter to equipment is

PPCFGM-MD系列氣箱脈沖袋收塵器

PPCFGM–MD Series Plenum Pulse Bag Filter

概述Introduction

PPCFGM系列袋收塵器主要適用于非爆炸性粉塵，可廣泛應用于建材、冶金寥行業的破碎機磨機，兩磨℃干找機、O-Sepa 眼機、兩冷卻機、包裝機等系統的收塵。

PPCFGM series bag filters are mainly applied to non-explosive dust. They are widely used to collect dust in crusher, ball mill, vertical mill, dryer, O-Sepa separator, grate cooler, packer, etc, in industries as building material, metallurgy, electrical power, etc.

特點簡介Characteristics

l能一次性處理含塵濃度高達1000g/Nm煙塵

l無需預收收塵設備，工藝流程簡單

l袋室內無需噴吹管，拆換袋方便

l嵌入式彈性袋口，密封性能好

l脈沖閥數量少，DMF-Y型電磁脈沖閥-DMF-Y型電磁脈沖閥生產廠家，清灰強度大，動作迅速

l整機采用微機自動控制，各控制參數易于調節，投入自動是，可實現無崗位工操作。

lAble to treat smoke with dust concentration 1000g/Nm at one time

lNo equipment for pre-collecting dust is necessary，which brings out a simple process flow

lwithout jet pipe in bag chamber，it is convenient to replace bags

lThe embedded elastic bag mouth helps in good sealing

lNumber of pulse values is small; operation of removing dust is highly efficient

lThe whole equipment is automatically controlled by computer. under automation mode，no person is needed for operation.

LMCDCDMC系列長袋脈沖布袋式除塵器

LMCDCDMC Series Long-Bag Pulse Bag Pulse Filter

特點簡介Characteristics

l設計新穎，采用下進氣結構，較粗的高溫顆粒直接落入灰斗?有效的保護濾袋

l采用長濾袋，在同等處理能力設備占地面積少，更便于老廠改造

l采用分室離線清灰，長袋離線脈沖除塵器-長袋離線脈沖除塵器生產廠家，效率高，粉塵的二次吸附少，同有效的降低設備能耗，濾袋與脈沖閥的疲勞程度也相應降低，成倍地提高濾袋和閥片的壽命，大量減少設備運行維護的費用

l檢修換袋可在不停系統風機、系統正運行的條件下分室進行

l濾袋袋口采用彈簧漲緊結構，拆裝方便，具有良好的密封性

l箱體經過氣密性設計，并以 撿漏， 程度減少漏風

l整TA-I設備由PLC機控制，實現自動清灰、卸灰、自動溫度控制及CA溫報警

l富宇環保opper directly to effectively protect filter bags.

lWith long bags, equipment takes less area compared with others in the same capacity. It is especially favorable for upgrading of existing plants.

lOff-line dust removal in separate chambers featured as follows: high efficiency: less secondary dust re-adhering: lower power consumption; extended service life of bags and valve plate due to less fatigue. in this way, expense for equipment maintenance could be greatly reduced.

lMaintenance and replacement of bag can be separately conducted in each chamber without interrupting the whole operation system and fans.

lApply spring take-up at bag mouth for easy maintenance and replacement and favorable air tightness.

lThe design of shell takes air tightness into consideration and use kerosene for inspection, so as to reduce air leakage to the largest extent.

lEquipment is controlled through PLC to realize automatic dust removal, dust discharge, temperature control and over-temperature alarming.

廠家,2020NA推薦產品,生物質鍋爐脈沖除塵器,燃煤鍋爐，生物質蒸拂配TA-O除塵器富宇廠家,2020NA推薦產品,生物質鍋爐脈沖除塵器,燃煤鍋爐，生生產廠家，型號齊全，價格合理，批發定做，圖片說明。